2002 MINI One: common problems and MOT failures
What MOT testers find on the MINI One first registered in 2002: we looked at the 181 MOTs these cars had during 2023–2025. Plus known faults and what to look at before you buy one.
Small sample: there were only 181 MOTs of these cars during 2023–2025, so treat the percentages as rough. The known faults below don't depend on it.
What goes wrong more than usual on a 2002 MINI One?
Parts flagged at MOT more often on the 2002 MINI One than on all cars registered in 2002.
- Rigid brake pipes2.2× usualMINI One40.3% All 2002 cars18.2%
Failed outright at MOT: 4.4%, against 2.8% of all 2002 cars. The rest were advisories or minor defects.
Rough price £100–£400 our estimateAt the viewing: Ask to see underneath, or check the MOT advisories: corroded brake or fuel pipes get worse every year and fail the MOT when they do.
- Number plate lights2.3× usualMINI One17.1% All 2002 cars7.4%
Failed outright at MOT: 3.3%, against 1.9% of all 2002 cars. The rest were advisories or minor defects.
Rough price £5–£40 our estimateAt the viewing: Check the number plate lights work and the plates are clean and legal.
Common 2002 MINI One MOT failures and advisories
The share of 2002 MINI One MOT tests where testers flagged each area, as a fail or an advisory. Rough prices are typical independent-garage costs.
- Brakes62% of testsRough price £150–£350
At the viewing: Look for a lip on the disc edges and feel for judder or pulling when braking firmly from about 40mph.
- Lights and electrics51% of testsRough price £10–£80
At the viewing: Ask a friend to check every light, including brake lights and indicators, while you operate them.
- Suspension50% of testsRough price £120–£400
At the viewing: Listen for knocks over speed bumps, and look behind each front wheel for a snapped coil spring.
- Tyres33% of testsRough price £70–£150
At the viewing: Check the tread on all four tyres, including the inside edges, and look for cracks or bulges.
- Oil and fluid leaks28% of testsRough price £80–£600
At the viewing: Look under the engine and on the ground where the car is usually parked for fresh oil or fluid.
- Wipers, windscreen and mirrors20% of testsRough price £15–£250
At the viewing: Check for chips in the driver's view, and test the wipers and washers.
Known faults on the 2002 MINI One
Reported by owners, mechanics and buying guides for this model and age. Check which engine the car has, as some apply to one engine only.
- 1.4 diesel
Head gasket and liner problems (1.4 diesel)
The 1.4 Toyota-made diesel is prone to head gasket and cylinder liner problems.
At the viewing: Check the coolant level and colour, and look for smoke from the exhaust.
- 1.6 petrol
Oil leaks and brittle plastics (1.6 petrol)
The 1.6 petrol can leak oil from the sump and cam cover gaskets. Plastic parts go brittle; if the dipstick handle breaks and falls into the sump it can wreck the engine.
At the viewing: Look for oil around the engine and underneath, and check the dipstick handle is intact.
- Petrol
Low oil pressure after servicing
Low oil pressure can mean the cartridge oil filter was fitted wrongly at the last service.
At the viewing: Make sure the oil warning light goes out straight after starting, and listen for tapping from the engine.
- Manual gearbox
Gearbox bearing and differential noise
Early cars used a Midland gearbox where a rattle or hum can mean a worn bearing, and clicking can mean a failing differential. The later Getrag box (from mid-2004) wears less but shouldn't jump out of gear.
At the viewing: Listen for rattles at idle and hums on the move, and make sure every gear engages and stays in.
- Petrol
Misfires and worn engine mounts
Worn coils or leads, or oil in the spark plug wells, cause misfires. Worn engine mounts cause judder when pulling away.
At the viewing: Check it idles smoothly and pulls away without judder.
- All engines
Water leaks and damp boot
The frameless front windows can seal badly, and the rear lights and tailgate handle trim often let water in.
At the viewing: Lift the boot floor and check for damp or a musty smell.
- All engines
Rust on neglected cars
Neglected cars can rust at the rear sill edges, around the front bumper and in the arches.
At the viewing: Look along the sills and wheel arches for bubbling paint.
Questions to ask the seller before buying a 2002 MINI One
Ask before you travel to see it. A seller who knows the car will have answers, and receipts.
- Has the head gasket ever been replaced, and does it lose coolant?
- Any recent work on the rigid brake pipes? (Flagged at MOT 2.2× as often on the 2002 MINI One as on other cars the same age.)
- Any recent work on the number plate lights? (Flagged at MOT 2.3× as often on the 2002 MINI One as on other cars the same age.)
- Can I see the service history and receipts for any big jobs?
Looking at a MINI One?
Check the actual car: its own MOT history, mileage and what to ask the seller. Free, no sign-up.
Other years
Every year of the MINI One compared
| Year | MOT tests | Most flagged |
|---|---|---|
| 2026 | – | Too new for MOT data |
| 2023 | – | Too new for MOT data |
| 2022 | 1,284 | Tyres 27% |
| 2021 | 2,698 | Tyres 27% |
| 2020 | 3,442 | Tyres 25% |
| 2019 | 4,588 | Tyres 28% |
| 2018 | 4,619 | Tyres 29% |
| 2017 | 15,961 | Tyres 33% |
| 2016 | 24,767 | Tyres 32% |
| 2015 | 31,025 | Tyres 30% |
| 2014 | 18,466 | Tyres 30% |
| 2013 | 21,196 | Tyres 31% |
| 2012 | 12,997 | Tyres 30% |
| 2011 | 3,168 | Tyres 33% |
| 2010 | 1,781 | Lights and electrics 33% |
| 2009 | 1,035 | Exhaust and emissions 31% |
| 2008 | 933 | Brakes 35% |
| 2007 | 848 | Lights and electrics 36% |
| 2006 | 610 | Brakes 52% |
| 2005 | 616 | Brakes 54% |
| 2004 | 449 | Brakes 59% |
| 2003 | 285 | Brakes 60% |
| 2001 | – | Too few tests |
Where this comes from: the DVSA's anonymised results for every MOT test done in Great Britain during 2023–2025, counting the MOTs of MINI One cars first registered in 2002. "Flagged" includes advisories, so it isn't the same as a fail rate. How we score